Jia Restaurant

Food properly labeled; original container — Inspector Note: Observed a cooked pork belly in the cooler without name and date. The PIC labeled and date marked it. 511-6-1.04(4)(d) - Food Storage Containers Identified with Common Name of Food (C) (d) Food Storage Containers, Identified with Common Name of Food. Except for containers holding food that can be readily and unmistakably recognized, such as dry pasta, working containers holding food or food ingredients that are removed from their original packages for use in the food establishment, such as cooking oils, flour, herbs, potato flakes, salt, spices, and sugar shall be clearly and legibly identified, in English, with the common name of the food.

Wiping cloths: properly used and stored — Inspector Note: Observed failure to properly store the in use wiping cloths in the kitchen. I advised the PIC to ensure all wiping cloths are placed back in a sanitizer water after use. 511-6-1.04(4)(m) - Wiping Cloths, Use Limitation (C) (m) Wiping Cloths, Use Limitation. 1. Cloths in-use for wiping food spills from tableware and carry-out containers that occur as food is being served shall be: (i) Maintained dry; and (ii) Used for no other purpose. 2. Cloths in-use for wiping counters and other equipment surfaces shall be: (i) Held between uses in a chemical sanitizer solution at a concentration specified under DPH Rule 511-6-1-.05(6)(n); and (ii) Laundered daily. 3. Cloths in-use for wiping surfaces in contact with raw animal foods shall be kept separate from cloths used for other purposes. 4. Dry wiping cloths and the chemical sanitizing solutions in which wet wiping cloths are held between uses shall be free of food debris and visible soil. 5. Containers of chemical sanitizing solutions in which wet wiping cloths are held between uses shall be stored off the floor and used in a manner that prevents contamination of food, equipment, utensils, linens, single-service, or single-use articles. 6. Single-use disposable sanitizer wipes shall be used in accordance with EPA-approved manufacturer’s label use instructions.

Nonfood-contact surfaces clean — Inspector Note: Observed stains, food residues on the refrigerators, walls and floor. The PIC shall clean the walls and floors. 511-6-1.05(7)(d) - Nonfood-Contact Surfaces (C) (d) Nonfood-Contact Surfaces. Nonfood-contact surfaces of equipment shall be cleaned at a frequency necessary to preclude accumulation of soil residues.

Proper eating, tasting, drinking, or tobacco use — Inspector Note: Observed a kitchen staff eating and drinking while in the kitchen. I advised the kitchen manager to correct the kitchen staff and he did. Employees shall consume food only in approved designated areas separate from food preparation and serving areas, equipment or utensil areas and food storage areas. However, drinking from a single service beverage cup with a secure lid and straw that is handled to prevent contamination of the employee’s hands, the container, exposed food, clean equipment, utensils and linens, unwrapped single-service and single-use articles will be allowed.

Adequate handwashing facilities supplied & accessible — Inspector Note: Observed that the kitchen hand sink cold water side is broken. The hand sink has no cold water. The PIC shall repair the cold water faucet. 511-6-1.06(2)(o) - Using a Handwashing Sink- Operation & maintenance (Pf) (o) Using a Handwashing Sink. 1. A handwashing sink shall be maintained so that it is accessible at all times for employee use. Pf 2. A handwashing facility may not be used for purposes other than handwashing. Pf 3. An automatic handwashing facility shall be used in accordance with manufacturer’s instructions. Pf

Food properly labeled; original container — Inspector Note: Observed failure to label sauces, oils and non easily recognizable seasonings at the time of the insepction. COS- items were labeled. 511-6-1.04(4)(d) - Food Storage Containers Identified with Common Name of Food (C) (d) Food Storage Containers, Identified with Common Name of Food. Except for containers holding food that can be readily and unmistakably recognized, such as dry pasta, working containers holding food or food ingredients that are removed from their original packages for use in the food establishment, such as cooking oils, flour, herbs, potato flakes, salt, spices, and sugar shall be clearly and legibly identified, in English, with the common name of the food.

Posted: Permit/Inspection/Choking Poster/Handwashing — Inspector Note: Observed no permit displayed as facility has not been paying permit fees. CA- facility must get caught up on fees and display the updated permit. 511-6-1.02(1)(f)(1) - Permit, Displayed (C) 1. Post the permit in a location in the food service establishment that is conspicuous to consumers

Single-use/single-service articles: properly stored, used — Inspector Note: Observed facility resuming grocery bags and soy sauce containers to hold food. CA- food grade bags shall be sued to store food not grocery bags and soy sauce containers may not be reused. 511-6-1.05(6)(r) - Single-Service/Single-Use Articles, Use Limitations (C) (r) Single-Service and Single-Use Articles, Use Limitation. 1. Single-service and single-use articles may not be reused.

Food and nonfood-contact surfaces cleanable, properly designed, constructed, and used — Inspector Note: Observed multiple stained preptop cooler cutting boards. CA- cutting boards shall be replaced or resurfaced if unable to be cleaned. 511-6-1.05(6)(b) - Cutting Surfaces (C) (b) Cutting Surfaces. Surfaces such as cutting blocks and boards that are subject to scratching and scoring shall be resurfaced if they can no longer be effectively cleaned and sanitized, or discarded if they cannot be resurfaced.

Warewashing facilities: installed, maintained, used; test strips — Inspector Note: Observed failure to provide quats test strips for the 3 compartment sink. CA- test strips shall be provided and used. 511-6-1.05(3)(h),(i),(j) - Temperature Measuring Device, Manual Warewashing; Sanitizing Solutions, Testing Device (Pf) (h) Temperature Measuring Devices, Manual and Mechanical Warewashing. (i) Sanitizing Solutions, Testing Devices. A test kit or other device that accurately measures the concentration in mg/L of sanitizing solutions shall be provided. Pf

Warewashing facilities: installed, maintained, used; test strips — Inspector Note: Observed no chemical for rinse at both dish machines at the time of the inspection. CA- dish machines shall not be used until chemicals are provided. 511-6-1.05(7)(j) - Rinsing Procedures (C) (j) Rinsing Procedures. Washed utensils and equipment shall be rinsed so that abrasives are removed and cleaning chemicals are removed or diluted through the use of water or a detergent-sanitizer solution by using one of the following procedures: 1. Use of a distinct, separate water rinse after washing and before sanitizing if using: (i) A 3-compartment sink, or (ii) A 3-step washing, rinsing, and sanitizing procedure in a warewashing system for CIP equipment; 2. Use of a detergent-sanitizer as specified under subsection (6)(o) of this Rule if using a warewashing system for CIP equipment; 3. If using a warewashing machine that does not recycle the sanitizing solution as specified under paragraph 4 of this subsection, or alternative manual warewashing equipment such as sprayers, use of a nondistinct water rinse must be: (i) Integrated in the application of the sanitizing solution, and (ii) Wasted immediately after each application; or 4. If using a warewashing machine that recycles the sanitizing solution for use in the next wash cycle, use of a nondistinct water rinse that is integrated in the application of the sanitizing solution.

Nonfood-contact surfaces clean — Inspector Note: Observed shelves throughout the main kitchen with debris. Ca- shelves shall be cleaned. 511-6-1.05(7)(a)2,3 - Equipment, Food/Nonfood-Contact Surfaces, and Utensils, food-contact surfaces of cooking equipment & nonfood-contact surfaces free of accumulations (C) 2. The food-contact surfaces of cooking equipment and pans shall be kept free of encrusted grease deposits and other soil accumulations. 3. Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris.

Adequate handwashing facilities supplied & accessible — Inspector Note: Observed no paper towels at the back hand sink at the time of the inspection. Observed no paper towels by the main hand sink at the beginning of the inspection. COS- paper towels were provided. 511-6-1.07(3)(b) - Hand Drying Provision (Pf) (b) Hand Drying Provision. Each handwashing sink or group of adjacent handwashing sinks shall be provided with: 1. Individual, disposable towels; Pf 2. A continuous towel system that supplies the user with a clean towel; Pf 3. A heated-air hand drying device; Pf or 4. A hand drying device that employs an air-knife system that delivers high velocity, pressurized air at ambient temperatures.Pf

Food separated and protected — Inspector Note: Observed raw steak in front of raw chicken on the preptop cooler. Observed raw chicken stored above raw beef in the RIC. COS- food was moved to appropriate places to prevent contamination. 511-6-1.04(4)(c)1(i)(ii)(iii)(v)(vi)(vii)(viii) - Packaged & Unpackaged Food Separation, Packaging, and Segregation (P, C) (c) Packaged and Unpackaged Food - Separation, Packaging, and Segregation. 1. Food shall be protected from cross contamination by: (i) Except as specified in paragraph (i)(IV) of this subsection, separating raw animal foods during storage, preparation, holding, and display from: (I) Raw ready-to-eat food including other raw animal food such as fish for sushi or molluscan shellfish, or other raw ready-to-eat food such as fruits and vegetables, P and (II) Cooked ready-to-eat food; and P (III) Fruits and vegetables before they are washed; P (IV) Frozen, commercially processed and packaged raw animal food may be stored or displayed with or above frozen, commercially processed and packaged, ready-to-eat food. (ii) Except when combined as ingredients, separating types of raw animal foods from each other such as beef, fish, lamb, pork, and poultry during storage, preparation, holding, and display by: (I) Using separate equipment for each type, P or (II) Arranging each type of food in equipment so that cross contamination of one type with another is prevented, P and (III) Preparing each type of food at different times or in separate areas; P (iii) Cleaning and sanitizing equipment and utensils;

Food-contact surfaces: cleaned & sanitized — Inspector Note: Observed no sanitizer available at both dish machines in the facility. CA- dish machines may not be used until sanitizer is provided. 511-6-1.05(6)(n) - Manual and Mechanical Warewashing Equipment, Chemical Sanitization-Temperature, pH, Concentration, Hardness (P,Pf) (n) Manual and Mechanical Warewashing Equipment, Chemical Sanitization - Temperature, pH, Concentration, and Hardness. A chemical sanitizer used in a sanitizing solution for a manual or mechanical operation at contact times specified under subsection (8)(b)3 of this Rule shall meet the requirements specified in DPH Rule 511-6-1-.07(6)(g), shall be used in accordance with the Environmental Protection Agency (EPA)-registered label use instructions P, and shall be used as follows: 1. A chlorine solution shall have a minimum temperature based on the concentration and pH of the solution as listed in the following chart; P Concentration Range Minimum Temperature MG/L PH 10 or less oF (oC) PH 8 or less oF (oC) 25-49 120 (49) 120 (49) 50-99 100 (38) 75 (24) 100 55 (13) 55 (13)

Food-contact surfaces: cleaned & sanitized — Inspector Note: Observed the interior of the ice machine with pink slime buildup on the top portion of the ice machine. CA- ice machine shall be cleaned . 511-6-1.05(7)(b) - Food Contact Surfaces and Utensils - Cleaning Frequency (P, C) (b) Equipment Food-Contact Surfaces and Utensils. 1. Equipment food-contact surfaces and utensils shall be cleaned: iv) In equipment such as ice bins and beverage dispensing nozzles and enclosed components of equipment such as ice makers, cooking oil storage tanks and distribution lines, beverage and syrup dispensing lines or tubes, coffee bean grinders, and water vending equipment: (I) At a frequency specified by the manufacturer; or (II) Absent manufacturer specifications, at a frequency necessary to preclude accumulation of soil or mold.

Proper cold holding temperatures — Inspector Note: Observed raw meats holing in the prep top cooler above 41F at the time of the inspection. COS- raw meats were removed. Observed cut cabbage holding on the counter at 55F. 511-6-1.04(6)(f) - Time/Temperature Control for Safety; Cold Holding (P) (f) Time/Temperature Control for Safety Food, Hot and Cold Holding. Except during preparation, cooking, or cooling, or when time is used as the public health control, time/temperature control for safety food shall be maintained at 41°F (5°C) or below or 135°F (57°C) or above, except that roasts cooked to a temperature and for a time specified in subsection (5)(a)2 of this Rule and reheated using the same temperature and time conditions as cooking may be held at a temperature of 130°F (54°C) or above. P

Proper date marking and disposition — Inspector Note: Observed failure to date mark cooked beef, cooked pork and cooked wontons in a RIC. COS- items were dated. 511-6-1.04(6)(g) - Ready-To-Eat Time/Temperature Control for Safety Food, Date Marking (Pf) (g) Ready-to-Eat Time/Temperature Control for Safety Food, Date Marking 1. Except when packaging food using a reduced oxygen packaging method, and except as specified in paragraphs 5 and 6 of this subsection, refrigerated, ready-to-eat, time/temperature control for safety food prepared and held in a food establishment for more than 24 hours shall be clearly marked to indicate the date or day by which the food shall be consumed on the premises, sold, or discarded, when held at a temperature of 41°F (5°C) or below for a maximum of 7 days. The day of preparation shall be counted as Day 1. Pf

Posted: Permit/Inspection/Choking Poster/Handwashing — Inspector Note: Observed the most recent inspection report not posted. CA- inspection received via email today shall be printed and posted. 511-6-1.02(1)(d) - Displaying of the Inspection Report (C) 1. The most current inspection report shall be prominently displayed in public view at all times, within fifteen feet of the front or primary public door and between five feet and seven feet from the floor and in an area where it can be read at a distance of one foot away.

In-use utensils: properly stored — Inspector Note: Observd utensil stored in water at 69 degrees for the rice cooker scoops and observed bar equipment stored in water below 135F. COS- items were removed from water. Observed scoop stored with the handle down inside flour. COS- scoop was moved with the handle above. 511-6-1.04(4)(k) - In-Use Utensils, Between-Use Storage (C) (k)Storage of In-Use Utensils. During pauses in food preparation or dispensing, food preparation and dispensing utensils shall be stored: 1.Except as specified under paragraph 2 of this subsection, in the food with their handles above the top of the food and the container; 2.In food that is not time/temperature control for safety food with their handles above the top of the food within containers or equipment that can be closed, such as bins of sugar, flour, or cinnamon; 3.On a clean portion of the food preparation table or cooking equipment only if the in-use utensil and the food-contact surface of the food preparation table or cooking equipment are cleaned and sanitized at a frequency specified under DPH Rule 511-6-1-.05(7)(b) and (8)(a); 4.In running water of sufficient velocity to flush particulates to the drain, if used with moist food such as ice cream or mashed potatoes; 5. In a clean, protected location if the utensils, such as ice scoops, are used only with a food that is not time/temperature control for safety food; or 6. In a container of water if the water is maintained at a temperature of at least 135°F (57°C) and the container is cleaned at a frequency specified under DPH Rule 511-6-1-.05(7)(b)3(vi).

Single-use/single-service articles: properly stored, used — Inspector Note: Observed facility resuming grocery bags to hold food. CA- food grade bags shall be sued to store food not grocery bags. 511-6-1.05(6)(r) - Single-Service/Single-Use Articles, Use Limitations (C) (r) Single-Service and Single-Use Articles, Use Limitation. 1. Single-service and single-use articles may not be reused.

Food and nonfood-contact surfaces cleanable, properly designed, constructed, and used — Inspector Note: Observed the gaskets not in good repair in a couple of the reach in coolers. CA- cooler gaskets shall be maintained in good repair. 511-6-1.05(6)(a) - Good Repair & Proper Adjustment (C) (6) Maintenance and Operation. (a) Good Repair and Proper Adjustment. 1. Equipment shall be maintained in a state of repair and condition that meets the requirements specified under subsections (1) and (2)of this Rule. 2. Equipment components such as doors, seals, hinges, fasteners, and kick plates shall be kept intact, tight, and adjusted in accordance with manufacturer's specifications. 3. Cutting or piercing parts of can openers shall be kept sharp to minimize the creation of metal fragments that can contaminate food when the container is opened.

Warewashing facilities: installed, maintained, used; test strips — Inspector Note: Observed failure to provide chlorine test strips to test the sanitizer contractions at the dish machines. Observed failure to provide quats test strips for the 3 compartment sink. CA- test strips shall be provided and used. 511-6-1.05(3)(h),(i),(j) - Temperature Measuring Device, Manual Warewashing; Sanitizing Solutions, Testing Device (Pf) (h) Temperature Measuring Devices, Manual and Mechanical Warewashing. (i) Sanitizing Solutions, Testing Devices. A test kit or other device that accurately measures the concentration in mg/L of sanitizing solutions shall be provided. Pf

Warewashing facilities: installed, maintained, used; test strips — Inspector Note: Observed failure to provide detergent at the bar dish machine. Observed quats sanitizer and two chlorine containers hooked up at the dish machine. COS- dish machine will not be used until ecolab brings the required chemicals.511-6-1.05(6)(g) - Warewashing Equipment, Cleaning Agents (Pf) (g) Warewashing Equipment, Cleaning Agents. When used for warewashing, the wash compartment of a sink or mechanical warewasher shall contain a wash solution of soap, detergent, acid cleaner, alkaline cleaner, degreaser, abrasive cleaner, or other cleaning agent according to the cleaning agent manufacturer's label instructions. Pf

Warewashing facilities: installed, maintained, used; test strips — Inspector Note: Observed failure to provide rinse solution at the bar dish machine. Observed quats sanitizer and two containers of chlorine sanitizer hooked up to the machine. COS- dish machine will not be used until ecolab brings the required chemicals. 511-6-1.05(7)(j) - Rinsing Procedures (C) (j) Rinsing Procedures. Washed utensils and equipment shall be rinsed so that abrasives are removed and cleaning chemicals are removed or diluted through the use of water or a detergent-sanitizer solution by using one of the following procedures: 1. Use of a distinct, separate water rinse after washing and before sanitizing if using: (i) A 3-compartment sink, or (ii) A 3-step washing, rinsing, and sanitizing procedure in a warewashing system for CIP equipment; 2. Use of a detergent-sanitizer as specified under subsection (6)(o) of this Rule if using a warewashing system for CIP equipment; 3. If using a warewashing machine that does not recycle the sanitizing solution as specified under paragraph 4 of this subsection, or alternative manual warewashing equipment such as sprayers, use of a nondistinct water rinse must be: (i) Integrated in the application of the sanitizing solution, and (ii) Wasted immediately after each application; or 4. If using a warewashing machine that recycles the sanitizing solution for use in the next wash cycle, use of a nondistinct water rinse that is integrated in the application of the sanitizing solution.

Nonfood-contact surfaces clean — Inspector Note: Observed shelves throughout the main kitchen with debris. Ca- shelves shall be cleaned. 511-6-1.05(7)(a)2,3 - Equipment, Food/Nonfood-Contact Surfaces, and Utensils, food-contact surfaces of cooking equipment & nonfood-contact surfaces free of accumulations (C) 2. The food-contact surfaces of cooking equipment and pans shall be kept free of encrusted grease deposits and other soil accumulations. 3. Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris.

Plumbing installed; proper backflow devices — Inspector Note: Observed a leak at the sanitier compartment of the 3 compartment sink. CA- leak shall be repaired. 511-6-1.06(2)(r) - System Maintained in Good Repair (P, C) (r) System Maintained in Good Repair. A plumbing system shall be repaired according to law; P and maintained in good repair.

Response procedures for vomiting & diarrheal events — Inspector Note: Observed failure to provide response procedures for contamination events. COS- PIC purchased a kit at the time of the inspection. 511-6-1.03(6) - Clean-up of Vomiting and Diarrheal Events(Pf) (6) Responding To Contamination Events. A food establishment shall have written procedures for employees to follow and an EPA registered disinfectant effective against Norovirus available on-site at the food service establishment when responding to vomiting or diarrheal events that involve the discharge of vomitus or fecal matter onto surfaces in the food service establishment. The procedures shall address the specific actions employees must take to minimize the spread of contamination and the exposure of employees, consumers, food, and surfaces to vomitus or fecal matter.Pf

Toxic substances properly identified, stored, used — Inspector Note: Observed a chemical bottle not labeled with the common name. COS- bottle was labeled. 511-6-1.07(6)(b) - Working Containers, Common Name (Pf) (b) Working Containers, Common Name. Working containers used for storing poisonous or toxic materials such as cleaners and sanitizers taken from bulk supplies shall be clearly and individually identified with the common name of the material. Pf