WNB Factory

Wiping cloths: properly used and stored — Inspector Note: Observed failure to store wiping clothes in a solution of sanitizer between use 511-6-1.04(4)(m) - Wiping Cloths, Use Limitation (C) (m) Wiping Cloths, Use Limitation. 1. Cloths in-use for wiping food spills from tableware and carry-out containers that occur as food is being served shall be: (i) Maintained dry; and (ii) Used for no other purpose. 2. Cloths in-use for wiping counters and other equipment surfaces shall be: (i) Held between uses in a chemical sanitizer solution at a concentration specified under DPH Rule 511-6-1-.05(6)(n); and (ii) Laundered daily. 3. Cloths in-use for wiping surfaces in contact with raw animal foods shall be kept separate from cloths used for other purposes. 4. Dry wiping cloths and the chemical sanitizing solutions in which wet wiping cloths are held between uses shall be free of food debris and visible soil. 5. Containers of chemical sanitizing solutions in which wet wiping cloths are held between uses shall be stored off the floor and used in a manner that prevents contamination of food, equipment, utensils, linens, single-service, or single-use articles. 6. Single-use disposable sanitizer wipes shall be used in accordance with EPA-approved manufacturer’s label use instructions. C.A; PIC instructed to ensure wiping clothes between use are stored in a solution of chemical sanitizer

Posted: Permit/Inspection/Choking Poster/Handwashing — Inspector Note: Observed failure to display the most recent inspection report 511-6-1.02(1)(d) - Displaying of the Inspection Report (C) 1. The most current inspection report shall be prominently displayed in public view at all times, within fifteen feet of the front or primary public door and between five feet and seven feet from the floor and in an area where it can be read at a distance of one foot away. C.A; PIC told to display the ,most recent inspection report

Food-contact surfaces: cleaned & sanitized — Inspector Note: Observed the interior flap of the ice machine with black buildup 511-6-1.05(7)(a)1 - Equipment, Food-Contact Surfaces,& Utensils (Pf) (7) Cleaning of Equipment and Utensils. (a) Equipment, Food-Contact Surfaces, and Utensils. 1. Equipment food-contact surfaces and utensils shall be clean to sight and touch. Pf. C.A: PIC instructed to toss the ice in the thrash and clean the ice machine

Food and nonfood-contact surfaces cleanable, properly designed, constructed, and used — Inspector Note: Observed household microwave being used for commercial use. PIC advised to only use commercial grade equipment for commercial use. 511-6-1.5 (2)(jj) - Food Service Equipment, Acceptability. Food service equipment must be commercial grade equipment and designed and built according to standards set by American National standards Institute (ANSI) accredited certification programs. Such an accredited program includes, but is not limited to, one offered by the National Sanitation Foundation, or Underwriters Laboratories. Food equipment that is certified or classified for sanitation by an American National Standards Institute (ANSI) accredited certification program is deemed to comply with subsections (1) and (2) of this Rule when used for its intended purpose.

Proper hot holding temperatures — Inspector Note: Observed cooked chicken wings being hot held at 87 degrees f. PIC COS by throwing out improperly hot held wings. 511-6-1.04(6)(f) - Time/Temperature Control for Safety; Hot Holding (P) (f) Time/Temperature Control for Safety Food, Hot and Cold Holding. Except during preparation, cooking, or cooling, or when time is used as the public health control, time/temperature control for safety food shall be maintained at 41°F (5°C) or below or 135°F (57°C) or above, except that roasts cooked to a temperature and for a time specified in subsection (5)(a)2 of this Rule and reheated using the same temperature and time conditions as cooking may be held at a temperature of 130°F (54°C) or above. P