Rock Steady

Contamination prevented during food preparation, storage, display — Inspector Note: Observed food items (cans of pineapple juice, cases of carbonated beverages not in plastic crates) stored on the floor of the outdoor storage area. Corrective action - PIC advised to provide shelving or racks to store foods at least 6 inches above the floor. 511-6-1.04(4)(q) - Food Storage (C) (q) Food Storage. 1. Except as specified in paragraphs 2 and 3 of this subsection, food shall be protected from contamination by storing the food: (i) In a clean, dry location; (ii) Where it is not exposed to splash, dust, or other contamination; and (iii) At least 6 inches (15 cm) above the floor. 2. Food in packages and working containers may be stored less than 6 inches (15 cm) above the floor on case lot handling equipment if the equipment can be moved by hand or by conveniently available apparatuses such as hand trucks and forklifts. 3. Pressurized beverage containers, cased food in waterproof containers such as bottles or cans, and milk containers in plastic crates may be stored on a floor that is clean and not exposed to floor moisture.

Wiping cloths: properly used and stored — Inspector Note: Observed wiping cloths stored in buckets without sanitizer. Corrected on site - PIC remade wiping cloth buckets with sanitizer at proper concentration. 511-6-1.04(4)(m) - Wiping Cloths, Use Limitation (C) (m) Wiping Cloths, Use Limitation. 1. Cloths in-use for wiping food spills from tableware and carry-out containers that occur as food is being served shall be: (i) Maintained dry; and (ii) Used for no other purpose. 2. Cloths in-use for wiping counters and other equipment surfaces shall be: (i) Held between uses in a chemical sanitizer solution at a concentration specified under DPH Rule 511-6-1-.05(6)(n); and (ii) Laundered daily. 3. Cloths in-use for wiping surfaces in contact with raw animal foods shall be kept separate from cloths used for other purposes. 4. Dry wiping cloths and the chemical sanitizing solutions in which wet wiping cloths are held between uses shall be free of food debris and visible soil. 5. Containers of chemical sanitizing solutions in which wet wiping cloths are held between uses shall be stored off the floor and used in a manner that prevents contamination of food, equipment, utensils, linens, single-service, or single-use articles. 6. Single-use disposable sanitizer wipes shall be used in accordance with EPA-approved manufacturer’s label use instructions.

Posted: Permit/Inspection/Choking Poster/Handwashing — Inspector Note: Observed that most recent inspection report not posted for public view. Corrected on site - PIC to post current inspection report. The most current inspection report shall be prominently displayed in public view at all times, within fifteen feet of the front or primary public door and between five feet and seven feet from the floor and in an area where it can be read at a distance of one foot away.

Food stored covered — Inspector Note: Observed containers of spices near cooking equipment stored uncovered. Corrective action - PIC advised to provide covers for spices when not in use. 511-6-1.04(4)(c)1(iv) - Packaged & Unpackaged Food, food stored covered (iv) Except as specified under paragraph 2. of this subsection and when cooling as specified in DPH Rule 511-6-1-.04(6)(e)2.(ii), storing the food in packages, covered containers, or wrappings, except for loosely covered or uncovered containers in which food is being cooled if protected from overhead contamination;

Food-contact surfaces: cleaned & sanitized — Inspector Note: Observed debris on the food-contact surfaces of plates stored as clean in kitchen area. Observed build up of food residue on can opener blade. Corrected on site - PIC relocated items to warewashing area for cleaning. 511-6-1.05(7)(a)1 - Equipment, Food-Contact Surfaces,& Utensils (7) Cleaning of Equipment and Utensils. (a) Equipment, Food-Contact Surfaces, and Utensils. 1. Equipment food-contact surfaces and utensils shall be clean to sight and touch.

Food-contact surfaces: cleaned & sanitized — Inspector Note: Observed low sanitizer concentration at mechanical dishwasher (0-100 ppm quaternary ammonium). Corrective action - PIC advised to use 3-compartment sink until sanitizer dispensing is repaired at mechanical dishwasher. 511-6-1.05(6)(n) - Manual and Mechanical Warewashing Equipment, Chemical Sanitization-Temperature, pH, Concentration, Hardness (n) Manual and Mechanical Warewashing Equipment, Chemical Sanitization - Temperature, pH, Concentration, and Hardness. A chemical sanitizer used in a sanitizing solution for a manual or mechanical operation at contact times specified under subsection (8)(b)3 of this Rule shall meet the requirements specified in DPH Rule 511-6-1-.07(6)(g), shall be used in accordance with the Environmental Protection Agency (EPA)-registered label use instructions

Food-contact surfaces: cleaned & sanitized — Inspector Note: Observed pink substance with the appearance of mold on the interior of the ice machine in the main kitchen area. Corrective action - PIC advised to increase frequency of cleaning and sanitizing of ice machine. 511-6-1.05(7)(a)1 - Equipment, Food-Contact Surfaces,& Utensils (7) Cleaning of Equipment and Utensils. (a) Equipment, Food-Contact Surfaces, and Utensils. 1. Equipment food-contact surfaces and utensils shall be clean to sight and touch.