Marco's Pizza

Contamination prevented during food preparation, storage, display — Inspector Note: Observed flour not protected from overhead contamination. Also observed uncovered sauce and cheese stored beneath dirty shelves in the food preparation area. 511-6-1.04(4)(z) - Miscellaneous Sources of Contamination (C) (z) Miscellaneous Sources of Contamination. Food shall be protected from contamination that may result from a factor or source not specified under paragraphs (a) through (y) of this subsection.

Posted: Permit/Inspection/Choking Poster/Handwashing — Inspector Note: Observed an expired food permit from the restaurant next door (El Catrin) posted in public view. PIC was advised to obtain a copy of the current food permit from the Henry County Health Department.

Nonfood-contact surfaces clean — Inspector Note: Observed build up on shelves above the preparation station. (Below shelves) 511-6-1.05(7)(a)2,3 - Equipment, Food/Nonfood-Contact Surfaces, and Utensils, food-contact surfaces of cooking equipment & nonfood-contact surfaces free of accumulations (C) 2. The food-contact surfaces of cooking equipment and pans shall be kept free of encrusted grease deposits and other soil accumulations. 3. Nonfood-contact surfaces of equipment shall be kept free of an accumulation of dust, dirt, food residue, and other debris.

Adequate ventilation and lighting; designated areas used — Inspector Note: Employee drink improperly stored above food in the reach in cooler. The drink was an open bottle. PIC corrected on site by discarding the drink bottle. 511-6-1.07(4)(b) - Designated Areas for Employee Activity, located to prevent contamination of food, equipment, utensils, linens, & single service articles (C) (b) Designated Areas for Employee Activity. 1. Areas designated for employees to eat, drink, use tobacco products and electronic devices shall be located so that food, equipment, linens, and single-service and single-use articles are protected from contamination. 2. Lockers or other suitable facilities shall be located in a designated room or area where contamination of food, equipment, utensils, linens and single-service and single-use articles cannot occur.

Proper cooling time and temperature — Inspector Note: Observed cooked wings not properly cooled from 135 to 70 degrees within 2 hours. Cooked wings observed at 96 degrees. Wings began cooling at 12:30. PIC corrected by reheating to 165 degrees and starting the cooling process again. 511-6-1.04(6)(d) - Cooling (P) (d) Cooling. 1. Cooked time/temperature control for safety food shall be cooled: (i) Within 2 hours from 135°F (57°C) to 70°F (21°C); P and (ii) Within a total of 6 hours from 135°F (57°C) to 41°F (5°C) or less. P 2. Time/temperature control for safety food shall be cooled within 4 hours to 41°F (5°C) or less if prepared from ingredients at ambient temperature, such as reconstituted foods and canned tuna. P 3. Except as specified under paragraph 4 of this subsection, a time/temperature control for safety food received in compliance with laws allowing a temperature above 41°F (5°C) during shipment from the supplier shall be cooled within 4 hours to 41°F (5°C). P 4. Raw eggs shall be received and immediately placed in refrigerated equipment that maintains an ambient air temperature of 41°F (5°C) or less. P Cooked Time/Temperature Control for Safety Food (Chicken wings) was not cooled from 135F to 70F within 2 hours.

Toxic substances properly identified, stored, used — Inspector Note: Observed a bottle of degreaser stored with clean dishes in the storage area. PIC relocated chemical bottle to the chemical storage area. 511-6-1.07(6)(c) - Storage, Separation (P) (c) Storage, Separation. Poisonous or toxic materials shall be stored so they cannot contaminate food, equipment, utensils, linens, and single-service and single-use articles by: 1. Separating the poisonous or toxic materials by spacing or partitioning; P and 2. Locating the poisonous or toxic materials in an area that is not above food, equipment, utensils, linens, and single-service or single-use articles. This requirement does not apply to equipment and utensil cleaners and sanitizers that are stored in warewashing areas for availability and convenience if the materials are stored to prevent contamination of food, equipment, utensils, linens, and single-service and single-use articles. P

Physical facilities installed, maintained, and clean — Inspector Note: Observed the walls and floors in need of cleaning underneath the 3-compartment sink and the clean dishes shelf. Observed the floor tile in front of the 3-compartment sink in bad repair. The floor tile must be replaced to prevent mold from growing underneath the tile.

Adequate ventilation and lighting; designated areas used — Inspector Note: Observed a light shield missing on the light in the unisex restroom.

Adequate ventilation and lighting; designated areas used — Inspector Note: Observed two water bottles with a top (half full) stored improperly in the kitchen and the walk in cooler. One bottle was on a shelf with sauces and single service items and another water bottle was stored above food items in the walk in cooler. Advised PIC to store employees items in a designated area (COS). 511-6-1.07(4)(b) - Designated Areas for Employee Activity, located to prevent contamination of food, equipment, utensils, linens, & single service articles (C) (b) Designated Areas for Employee Activity. 1. Areas designated for employees to eat, drink, use tobacco products and electronic devices shall be located so that food, equipment, linens, and single-service and single-use articles are protected from contamination. 2. Lockers or other suitable facilities shall be located in a designated room or area where contamination of food, equipment, utensils, linens and single-service and single-use articles cannot occur.

Insects, rodents, and animals not present — Inspector Note: Observed the back door of the establishment propped open during the majority of the inspection. PIC stated that it was propped open to take trash out. Advised staff to close the door immediately after taking the trash out (COS). 511-6-1.07(2)(m) - Outer Openings Protected (C) (m) Outer Openings, Protected. 1. Except as specified in paragraphs 2 through 5 of this subsection, outer openings of a food service establishment shall be protected against the entry of insects and rodents by: (i) Filling or closing holes and other gaps along floors, walls, and ceilings; (ii) Closed, tight-fitting windows; and (iii) Solid, self-closing, tight-fitting doors. 2. The requirements in paragraph 1 of this subsection does not apply if a food service establishment opens into a larger structure, such as a mall, airport, or office building, or into an attached structure, such as a porch, and the outer openings from the larger or attached structure are protected against the entry of insects and rodents. 3. Exterior doors used as exits need not be self-closing if they are: (i) Solid and tight-fitting; (ii) Designated for use only when an emergency exists, by the fire protection authority that has jurisdiction over the food establishment; and (iii) Limited-use so they are not used for entrance or exit from the building for purposes other than the designated emergency exit use. 4. Except as specified in paragraphs 2 and 5 of this subsection, if the windows or doors of a food service establishment, or of a larger structure within which a food service establishment is located, are kept open for ventilation or other purposes or a temporary food service establishment is not provided with windows and doors as specified under paragraph 1 of this subsection, the openings shall be protected against the entry of insects and rodents by: (i) 16 mesh to 1 inch (16 mesh to 25.4 mm) screens; (ii) Properly designed and installed air curtains to control flying insects; or (iii) Other effective means. 5. The requirement in paragraph 4 of this subsection does not apply if flying insects and other pests are absent due to the location of the establishment, the weather, or other limiting condition.